Sony BKDW-515 Installation And Maintenance Manual
Digital video cassette recorder
Hide thumbs
Also See for BKDW-515:
- Service manual (164 pages) ,
- Manuel de fonctionnement (164 pages) ,
- Maintenance manual (554 pages)
Related Manuals for Sony BKDW-515
Summary of Contents for Sony BKDW-515
- Page 1 DIGITAL VIDEOCASSETTE RECORDER DVW-A500/1 DVW-500/1 DVW-A500P/1 DVW-500P/1 CONTROL PANEL BKDW-515 INSTALLATION AND MAINTENANCE MANUAL 1st Edition (Revised 3)
- Page 2 Pour toute réparation faire appel à une personne compétente uniquement. DVW-A500/1 Serial No. 50001 and Higher DVW-500/1 Serial No. 50001 and Higher DVW-A500P/1 Serial No. 50001 and Higher DVW-500P/1 Serial No. 50001 and Higher BKDW-515 Serial No. 10001 and Higher BKDW-515 BKDW-515...
- Page 3 Udskiftning må kun ske med batteri af samme fabrikat og type. Levér det brugte batteri tilbage til leverandøren. BKDW-515 Voor de klanten in Nederland Dit apparaat bevat een (CF)n-Li batterij voor memory back-up. Raadpleeg uw leverancier over de verwijdering van de batterij op het moment dat u het apparaat bij einde levensduur afdankt.
-
Page 5: Table Of Contents
Current Setup Data Occurs ... 2-4 2-4-2. Correction when Checksum Error of VTR Bank Data Occurs ... 2-4 2-4-3. Correction when Checksum Error of Memory Card Data Occurs ... 2-4 3. Setup Menu 3-1. ITEM-F Series ... 3-1 BKDW-515 Table of Contents... - Page 6 Notes on Repair Parts ... 6-1 6-2. Spare Parts List for VTR ... 6-2 6-3. Packing Materials and Supplied Accessories List for VTR ... 6-3 6-4. Spare Parts List for Control Panel ... 6-4 Packing Materials and Supplied Accessories List for BKDW-515 ... 6-6 BKDW-515...
-
Page 7: Manual Structure
BKDW-515 Manual Structure This Manual describes the installation instructions for the digital videocassette recorder DVW-A500/1, 500/1, A500P/1, 500P/1 and the Control panel BKDW-515. This manual contains the information necessary when supplying and installing the unit, assuming use by system/service engineers. -
Page 8: Relative Manuals
These manuals describes detailed information necessary for general parts replace- ment and includes alignments, schematic diagrams, board layouts, detailed parts list, etc. Please contact the Sony service organization to obtain a copy of the manuals. • Protocol Manual (available on request) PROTOCOL OF REMOTE-1 (9Pin) CONNECTOR This Manual describes the protocol information necessary for controlling the VTR via RS-422A (9-pin serial remote). -
Page 9: Installation
The BKDW-515 cannot be installed in the BKDW-511 Control Panel Case. for DVW-A500/1, DVW500/1, DVW-A500P/1, DVW-500P/1 1-1. Installation of Control Panel 1. Fix a dummy panel for shipping use at 90 degrees. 2. Loosen the two black screws on the dummy panel. -
Page 10: Sys1, Sys2 Rom Versions
1-3. Removal of Control Panel / Replacement of Arms for DVW-A500, DVW500, DVW-A500P, DVW-500P 1-2. SYS1, SYS2 ROM Versions The control panel BKDW-515 is applicable to the ROMs on the SS-52 board with the following version. SYS1: 4.0 and higher SYS2: 4.0 and higher If the ROMs with lower version than above are used, please contact Sony’s service organization. -
Page 11: Installation Of Sub Panel Cover And Switch Cover
1-4. Installation of Sub Panel Cover and Switch Cover 1. Install the sub panel cover supplied with BKDW-515 to sub control panel. Screw (BVTT3x6) Sub panel cover Screw (BVTT3x6) 2. Install the switch cover supplied with BKDW-515 to system set-up panel. -
Page 12: Installation Space
FLEXICART, you can install both of BKDW-514/ 515 to the recorder. DVW-A500/1 500/1 A500P/1 500P/1 BKDW-515 377.4 80.4 177.6 As for how to mount the unit in a rack, refer to the Installa- tion Manual supplied with the DVW series. -
Page 13: Full Reset Of Control Panel
. AC Adapter Sony Part No.: 1-473-822-11 . Connector Box Sony Part No.: A-8277-618-A The control panel BKDW-515 can not be installed to the control panel case BKDW-511 (sold separately). Connection . AC100V and AC200V acceptable for AC adapter . There is power switch on the connector box. - Page 14 VTR for storing the Current Setup setting data in bank memory of VTR or in the memory card before- hand. After that, connect the two BKDW-515 to a single VTR, turn on the power of both BKDW-515, then copy the memorized data into Current Setup.
-
Page 15: Service Information
Board Name Circuit Function CP-266 Panel Control CPU, EL Control, PIO, Memory Card I/F KY-330 Editing Operation/Tape Transport Control Switches, Memory Card Connector SW-749 Function Control Switches PTC-69 JOG/Shuttle Dial Sensor CP-266 BKDW-515 Section 2 Service Information SW-749 KY-330 PTC-69... -
Page 16: Replacing The Battery For Memory Backup
5. Align a new battery for memory backup with the 1-pin mark of IC113, then insert. 6. Assemble the control panel and install it in the unit. 7. Access the data in a memory card. Screw . BT1 : 1-767-156-11 M4T28-BR12SH1 (lithium battery) (BVTT3x6) Mark IC113 CP-266 Flatbladed screwdriver BKDW-515... -
Page 17: El Panel Replacement
Screws(BVTT3x6) Cover Screw (BVTT3x6) Screws (BVTT3x6) SW-749 Screws (BVTT3x6) BKDW-515 5. Disconnect connector CN7 on the CP-266 board and remove the four screws, then remove the EL panel. Screws (PSW3x10) Screw (BVTT3x6) CP266 Screw (BVTT3x6) 6. Confirm that no dust adheres on the panel and install in the reverse order of steps 1 to 5. -
Page 18: Error Message
“Data DAMAGED” is displayed on the EL panel. Confirm the destroyed bank data or cue set data and copy normal data. The title of the destroyed data is displayed as “DAMAGED” (for only WRITE PRO- TECT OFF in a memory card). BKDW-515... -
Page 19: Setup Menu
PROTECTION CONFI SELECT disable IN PB MODE enable BKDW-515 Section 3 Setup Menu Description This item is prepared exclusively for audio adjustment. After adjustment is completed, return to the factory setting ‘0 (on)’. Select the type of control to turn Dolby noise reduction ON in the metal tape playback. - Page 20 Note: The whole operations of the VTR including TTP is not influenced at all even if this item is set to “0000” or “except 0000”. For except DATA: 0000 (factory setting), the control from 9 pin is not guaranteed. BKDW-515...
- Page 21 SEARCH MODE . CP ROM version 1.10 and higher BKDW-515 Description The condition to light CONFI LED on the control panel is selected. 0: CONFI LED lights on when CONFI switch is set to ON. 1: CONFI LED lights on when playing back with CONFI head. Note that CONFI LED indicates the switch status only during the CONFI switch is pressed.
-
Page 23: Maintenance Menu
“Maintenance Mode” of the DVW-A500 Series Mainte- nance Manual. In Part 1, “Maintenance Mode” of the DVW-A500 Series Maintenance Manual, change the following during use. [KY] 8 [CP] BKDW-515 Section 4 Maintenance Menu 4-2. VTR Maintenance Menu The self-diagnosis and adjustment of the VTR can be performed in this VTR maintenance menu. -
Page 24: Panel Maintenance Menu
FAILED.” is displayed, the card interface or card is defective. 4-3-2. Buzzer Test A buzzer test is executed. The setting changes to high, low, then high every time the F5 key is pressed. The sound in the displayed level is then generated. BKDW-515... -
Page 25: El Panel Test
The test can be executed no longer. To terminate the test halfway, press the SHIFT and CLR keys simultaneously. BKDW-515 4-3. Panel Maintenance Menu 4-3-5. Dial Test Interface test between search dial and dial interface is executed. -
Page 26: Error Logger
3. To erase the block sign, press the F9 (VTR HOLD) key and turn on the VTR HOLD. Error Logger Data Erasure To erase the error logger data, press the F5 (CLEAR LOG) key in the error logger screen display. BKDW-515... -
Page 27: Block Diagram
Overall BKDW-515 Section 5 Block Diagram OVERALL OVERALL BKDW-515... -
Page 29: Spare Parts
Therefore, specified parts should be used in the case of replacement. 2. Standardization of Parts Some repair parts supplied by Sony differ from those used for the unit. These are because of parts common- ality and improvement. Parts list has the present standardized repair parts. -
Page 30: Spare Parts List For Vtr
Ref. No. or Q’ty Part No. SP Description A-8278-252-A o PANEL ASSY, DUMMY X-3678-375-3 s SLIDER AD(R)ASSY X-3678-376-3 s SLIDER AD(L)ASSY 3-689-875-01 o COVER,SWC 3-689-879-02 o COVER,SUB PANEL BVTT3 x 6 BVTT3 x 6 B3 x 6 B3 x 6 BKDW-515... -
Page 31: Packing Materials And Supplied Accessories List For Vtr
3-189-457-01 o SPACER (C) 3-189-460-01 o INDIVIDUAL CARTON (for DVW-A500P/1) 3-189-461-01 o INDIVIDUAL CARTON (for DVW-500P/1) 3-701-634-00 o BAG, POLYETHYLENE (for S/N 50001 thru. 50110:DVW-A500/1(CE)) (for S/N 50001 thru. 50080:DVW-500/1(CE)) 4pcs 7-682-965-01 s SCREW +PSW 4x16 BKDW-515 DVW-A500/1, 500/1, A500P/1, 500P/1... -
Page 32: Spare Parts List For Control Panel
N 2.6 N 2.6 PSW3 x 6 PTPWH 2.6 x 5 N 2.6 PSW3 x 10 PSW3 x 6 PS2.6 x 10 N 2.6 PSW3 x 6 PSW3 x 6 PS2.6 x 10 BVTT3 x 6 BVTT3 x 6 BKDW-515... - Page 33 PWH2.6 x 5 E-4.0 BVTP3 x 8 B3 x 14 BKDW-515 BVTP3 x 8 Part No. A-8267-410-D s DIAL ASSY, SEARCH A-8276-585-A o MOUNTED CIRCUIT BOARD, PTC-69 BVTP3 x 8 1-454-606-11 s SOLENOID, PLUNGER 2-124-691-01 s ROLLER 2-124-693-02 s PLATE...
-
Page 34: Packing Materials And Supplied Accessories List For Bkdw-515
BKDW-515 6-5. Packing Materials and Supplied Accessories List for BKDW-515 Ref. No. or Q’ty Part No. SP Description X-3678-375-3 s SLIDER AD(R)ASSY X-3678-376-3 s SLIDER AD(L)ASSY 1-759-164-11 s CARD, MEMORY (SRAM 64K BYTE) 3-189-075-01 o SPACER (B) 3-189-076-01 o BOX, ACCESSORY... - Page 35 The material contained in this manual consists of information that is the property of Sony Corporation and is intended solely for use by the purchasers of the equipment described in this manual. Sony Corporation expressly prohibits the duplication of any portion of this manual or the use thereof for any...
- Page 36 DVW-A500/1 (UC) DVW-500/1 (UC) DVW-A500P/1 (CE) DVW-500P/1 (CE) Printed in Japan Sony Corporation BKDW-515 (WW) E 2003. 11 08 B&P Company 3-188-821-04 (2) ©1995...